Seller Said This Rare 500cc Supermoto Won't Run (Sitting 15 Years)
Переглядів 169,645
27 днів томуI buy a 2001 Husaberg 500cc supermoto that hasn't ran in over 15 years. Will it start? #Husaberg, #DirtBike, #Rare,
►SUBSCRIBE: / @2vintage
►MY SECOND CHANNEL: • New Polaris ATV Snow P...
► ADD ME ON ALL SOCIAL MEDIA ◄
► FACEBOOK: / 2vintageyoutube
► INSTAGRAM: 2_vintage_ / 2_vintage_
► SNAPCHAT the2vintage
► EMAIL FOR BUSINESS INQUIRIES ONLY: 2vintagetooo@gmail.com
Thanks for watching and subscribing!
New videos every week!
The following video features activities performed in controlled environments by knowledgeable persons. DO NOT attempt to duplicate, re-create, or perform the same or similar activities at home, as personal injury or property damage may result. 2vintage( Joe Weber, the persons shown in this video and ANY CONTRIBUTOR, ARE NOT LIABLE FOR ANY such injury or damage. ALL 2vintage( Joe Weber) CONTENT IS FOR ENTERTAINMENT PURPOSES ONLY.
2vintage (Joe Weber) makes no representation about the sufficiency of any safety precautions and equipment used in this video.
@minnesotatomcat 26 днів тому
It’s about time you break that left boot in! 😂
@k-mc94 26 днів тому
😆
@josephcanova4810 26 днів тому
Awesome!!!! Lol
@wreckum56 26 днів тому
Yup
@alexjohnson1612 23 дні тому
I wish my yz was left kick, its got high compression with being a supersport & I'm left footed 😂
@elev8j10 22 дні тому
I think the stator is haunted. Maybe a Swedish ritual of some sort will take care of it.
@marcusschwarzrock928 26 днів тому
Hi, i was glad to ride a 500 SX from 1995. Started like yours. Here my Tipp: Bike off from the Stand. Left Leg on the Stand, bike is leaning to you. And from the higher place on your Stand, ist easyer to let your body weight get on the Kickstart. I take it from older Maico 500 crossers.
@pjm204 26 днів тому
From what I remember the weakest link on these was the SEM ignition system. Since they were such an issue, I think a replacement is likely available.
@thebrokenbiker869 26 днів тому
It sounds like timing is out. I agree with you Joe. I also think you need to swap out the battery. In my experience a low battery will cut the spark current.
@scottwolverine3062 23 дні тому
but he hooked a fully charged jump pack by passing the battery
@Ed-G 19 днів тому
Charge the battery and replace the plug and wire (with coil if needed). Intermittent spark is hard to diagnose. When you had spark it was consistent and steady. When you did not. You had nothing. Which tells me it's probably the wire. Wires could go bad and they'll look just fine. Wires are extremely hard to test and requires specialized equipment, so just replace it.
@ghettsumm7949 26 днів тому
I think that pulling out the starter motor would have been a lot less effort, What a PITA! Good job Joe.
@jaijua2348 26 днів тому
What a job! It's a pleasure to see that you don't give up. Husaberg 2t and 4t were marketed here in Spain until 2012/13, especially the 2 strokes, the 4 strokes failed a lot, starting problems and valves, like the first crf450 02. Here in Europe there were different "rare" brands such as Vor or Vertemati, perimeter chassis, chain on the right, starter on the left, engines larger than 500cc and with Frankenstein aesthetics, in the 90s/00s, even here in Spain it took a long time get spare parts for them, the price was not competitive with the Japanese ones, they broke a lot and were expensive to maintain.
@wannaseethevid 26 днів тому
Yeah it took em' a while to figure out that decompression thing, I remember when the 400 and 426 yamaha's first hit the tracks here in Japan, thankfully they got it figured out but, well, I still reckon 2 smokers are more fun.
@coolnerdsclothing6377 25 днів тому
Thats either a FS400 or a FC550 but neither is 500cc how dont you know what it is if you know all this?
@connorwilson8078 24 дні тому
Husaberg are ktm, ktms first every racing 4 stroke , ktm bought it originally because they needed a racing 4 stroke in time after 4/ ban in racing in US, ktm took company on
@jaijua2348 24 дні тому
@@coolnerdsclothing6377 Be it 400 or 503 it is the same, but with a different race, at KTM it was the same, in the 2000s they had the sx400 and the sx520, both identical but with a larger piston and connecting rod, nothing more.
@VitruviunMan 26 днів тому
Nicely done Joe reminds me of starting the old 426’s such a pain in the arse!
@user-hj5ml8rr8u 26 днів тому
FYI.. the weakness of these things were wiring was thin and broke easily...the engine only holds 3/4 of a quart... if you want the engine to last more than a couple rides, it is a must to run Redline or maxima ester synthetic...My dealer at the time had the engineer from Sweden fly over because they were having so many problems ...the dealer also had a lot of stator issues... treating the stator cryogenically made them last twice as long...
@PaulHigginbothamSr 26 днів тому
What a terrible bike. NOT WANTED HERE. This better ride like a mad Ruzzian. I would NEVER add ethanol gas to this supposed bike. Poorly done. Maybe nitro-methane. Very bad wiring.
@ianmangham4570 26 днів тому
Dang it ,sounds nasty
@njmxjunkie3128 26 днів тому
No point explaining anything to him, he doesn’t read or respond to fucking comments
@unstoppableplayz6948 26 днів тому
Nice inside info 👌
@CoralReef69 26 днів тому
3/4 of a quart 😂😂
@Danman1972 26 днів тому
Had a buddy that had a 620 one. Crazy fast! I did get to take a ride on it and test the speed in an open sandy creek. IF you can't find a filter for it I had a buddy that made a filter out a universal kit from uni and a specific kind of hot glue. Was pretty nice when it was done.
@kenbassett5942 26 днів тому
I just want to say I love your channel. I was a teenager in the seventies and we rode alot of the bikes you feature here. I never miss a video. I love how you never get worked up. Your demeaner is great along with how you explain and go about things. My first dirt bike was an Ossa. I had a friend that rode a Hodaka, I think it was called the Wombat? Keep up the great content, love it!
@stkyfngrszmooth 25 днів тому
Patience is the number two necessary requirement for being a good mechanic. Number one is knowledge.
@LukeBarton-eh9ps 24 дні тому
Combat wombat I reckon
@Hanky_Bannist8r 26 днів тому
I know absolutely zero about Husabergs. But, i would be digging into the magneto side to make sure its rust free and check to see it is has a pulse generator. If it is also rusty or too far away from the magneto it can cause the same issue its having. With these bikes you just never know what kind of kooky setups they have.
@johnhicks735 26 днів тому
On those CDI boxes the ground wires can flip.,or have 2 of them to. The stator ground wire and the common ground through frame body to the common ground lead wires into the main wiring harness itself tied in together as one system.
@wurthmannd024 26 днів тому
Tech tip for you. The wire extensions you added at the plug when testing stator resistance will add to the resistance level. Also best practice to test Ohms without your body/fingers touching the wire.
@InternetzVideoz 25 днів тому
My addition is that I've had snowmobiles with heated grips. When could, with grip heaters on, would never start. Turn the heaters off... Fires right up, and then would fire warm with heaters on. Lesson here is to reduce all voltage draws possible, including factory dash/lights. Will narrow problems, and might find the draw.
@chrisziegerink500 23 дні тому
Those wires were really thick, it would've added milliohms at the most
@scotttaggart71 26 днів тому
Lost my lower right leg in a bike crash years ago. My coworker knew I loved to ride, he offered to let me try his new 68 Norton Commando, I got on the bike, and he said oh yeh, the shifter is on the right, I was so pissed off, I could not shift with my wooden leg...
@snowyowl7042 26 днів тому
😢Hope you are better now.
@Liesthroughisteeth 24 дні тому
I still have two Ducati RT450s from 71 (seldom seen Ducati dirt bikes) , bought in early 80s. Being a Canuk I was raised on Japanese bikes through the 60s and 70s shifting on the left. The Dukes were a blast to ride, until you find yourself hitting a somewhat unexpected steep downhill and go to hit the brake with your right only to find you've shifted up a gear. :D Good times.
@garrysimmons111 26 днів тому
This brought back memories of trying to start my early 80s Husqvarna 500XC. What a beast (when it ran). Such a PITA most of the time though. So glad my 530 EXC has the magic button (in addition to a kicker).
@philcal2000 26 днів тому
I have the 600 model when it's set right all you need is one kick with choke and one without, and it will start... good luck look forward to your next video.
@ranchdog7920 25 днів тому
I appreciate your tenacity. Those left side kickers build character. My first one was a Honda CR480 from the early 80’s.
@Mickbono06 26 днів тому
What a beautiful and rare machine, looks an absolute beast. Love it when you get rare and different dirt bikes. Looking forward to the outcome, best of luck bro 💯🤙🏻
@stkyfngrszmooth 26 днів тому
Plus, up close, it looks to be in very good condition.
@bruceskousen5451 26 днів тому
@@stkyfngrszmooththat’s because it was rarely ridden because it rarely started…😂
@Mickbono06 25 днів тому
@bruceskousen5451 😂😂
@bmusic0912 26 днів тому
But don’t forget, hussberg was just ahead of their time on designs. Some bikes were made poorly, but others were amazing. Graham Jarvis rode a husaberg for many years
@BricoleurTV 26 днів тому
They were a pain to start but once running they were great! There are a lot of Husaberg-experts here in Sweden and still some parts here and there, just tell us if there's anything you need... The Hi and Lo is for switching between ignition-curves (pointy or flat for enduro-riding) more than something for Hi-ways 😂
@danieldeboard9379 26 днів тому
Dang, love the bikes that give you a real challenge 😊 cant wait to see the next video on this thing.
@georgeheisch4681 22 дні тому
Your videos are like ASMR lol. I love the part of your videos when you tear into the carb. Also learning a little bit while watching. Great channel!
@user-fi3fx5my2s 26 днів тому
My uncle in Denver has that same bike but 400. Very quick, not to many gripes with it. I bet that one is a real beast with a 500 in it. Cool find..
@mototrailz 25 днів тому
46:44 here's you kill switch the red button. This handlebar switch is called CEV switch and KTM still uses it on rally bikes and enduro 👍
@chrisktm2010 26 днів тому
That’s not a supermoto it’s an enduro
@ctbale1 25 днів тому
"Joe don't know"
@leyuoo3338 25 днів тому
☝️🤓
@user-fi3fx5my2s 26 днів тому
That bike is worth tearing down the bd a repairing and cleaning. Sweet find man. Been trying to get my uncle to sell me his for long time, won't do it, loves it to much. Great little Enduro.
@johnkucin4482 26 днів тому
Wow! You are the man, I would of gave up after 325 kicks. My knee started hurting and I took a couple of Advice in your honor.
@Andy-vg7rh 26 днів тому
we got a lot of these in the uk. A friend had one a while ago. left hand kickstart no electric start. have fun with that lol
@Anthonyy19922 26 днів тому
i’ve seen a leg be tore to shreds lol.
@minibikemadman 26 днів тому
the old husky 500 2 strokes were wild to kick on the left side. These things are electrical nightmares to work on...they work one moment and it dies and you can't get em fired back up..they are some cool bikes from the early 4 stroke days.
@stkyfngrszmooth 26 днів тому
Smart riders learned to only shut these off on top of a hill.
@James-tu7vo 13 днів тому
Husaburgs are notorious for not starting especially when warm, if it don't start in three kicks it never will, put it back in van and grab a beer instead
@allan9603 26 днів тому
Joe, save your knees, joints, gonads.., later down the line and get you a roller starter. Amazon, Ebay Motors.., have them on the cheap.
@stkyfngrszmooth 26 днів тому
Those are incredibly handy. Especially with giant bombs like this thing.
@kryten1021 26 днів тому
Some of those old bergs used to be very prone to backfiring and blowing the carb clean out of the intake boot. I've seen riders destroyed before they get to the start gate just with the effort trying to kickstart their bikes while others seem to have the knack and start them up easily in trainers
@RimjobHimself 25 днів тому
Lol yes. Had a Husaberg last year. Blew off the carb. I had no idea why it wouldn't restart for a while. I was like wtf!!
@kryten1021 25 днів тому
@@RimjobHimself my mates did the same he kicked it for ages and then we towed it with the car 1/4 mile of 30 to 40 mph towing to no avail then eventually we spotted it and put it back in and it started first kick , we spoke to the UK berg importer Dave Clarke racing who was local to us and he said it's a common thing that would be around 2002. he demonstrated started one from cold in trainers when my mate was having all his problems, another mate ended up with an ex factory Joel Smets 600 from DCR think it was a 1996 ex mxgp bike that only had 3 speeds and all 3 gears were down, awesome tractor like pulling power strange gear set up but Smets won the 500cc world championship in 1995, 1997, 1998, and 2000 so i guess it worked
@dalebrown2271 22 дні тому
Awe man! this is a blast from my past! I bought one of these from new decades ago! had an original 501...was a complete beast! turned it into a Supermoto and raced it! Flames used to lick out the pipe when I was warming it up! Cold start was total crapshoot!
@cobbleup 26 днів тому
The internal spring/piston/ roller mechanism in the flywheel can get sticky from sitting . Once the engine has been warmed up to allow lubricants to those little springs/pistons//rollers they will “miraculously” loosen up and allow the necessary contact with their hub . I had this same issue with my 81 gl650. In the future I may try filling the crankcase to where the springs/pistons/rollers are submersed in oil for a period of time to assure that they can slide freely. Maybe fill with atf or marvel mystery oil as these oils are lighter and high detergent.
@DealinDmg 25 днів тому
I've never heard of that manufacturer. This was a first for me. Once you said it was a 500cc. I knew your leg was in for one hell of a workout. I was stoked when you got it to pop over. Looking forward to next video. I'm definitely interested in finding out what's causing the inconsistent spark/no start. Hopefully you can keep that starter spinning the motor over to save the Leg
@Skyisnotalimit 26 днів тому
The models with yellow pained frame, it’s the same paint as ESAB welders. Husaberg had their parts painted at their company back then.
@minnesotatomcat 26 днів тому
Cool bike, I’ve heard of them but never seen one before! I’m even Swedish! Kicking it over left footed would take awhile to get used to 🤣
@GTAADDICT3D 26 днів тому
Really got yourself a good workout that day. Cool bike!
@kellyriffle4750 26 днів тому
Had the Husaberg 650 Super Moto… Bad azz bike! FAST! LIGHT! Very minimal. Absolutely loved it! Required as much maintenance as a Japanese 4 stroke Mx bike,but the reason I sold it was parts availability.
@flangmasterj 25 днів тому
I was actually lucky enough to ride two of them. By far the most fun bikes I've ridden. Weird thing was they were learner approved over here in New Zealand.
@DadBeard-pi2oy 24 дні тому
yep I had a 94 501 it was fast and super light bike was way ahead of its time. Mine broke a intake valve stem trashed head and piston. Have fun with Left Leg Days!!
@kellyriffle4750 24 дні тому
@@DadBeard-pi2oy Lol! I used the magic button!!! lol
@joski9030 23 дні тому
@@kellyriffle4750The starter motors were known to not have enough beans on the FSE 650. My dad would kick his first time every time knowing what tdc is helps or you’ll kick until your sweating and swearing
@kellyriffle4750 23 дні тому
@@joski9030 No starter issues with the one I owned.
@al4904 22 дні тому
Hey Joe, a good mate of mine has a strange Husaberg obsession and has owned a 501 since new. I have just sent him a link to your video. If he offers any pearls of wisdom I shall pass them on to you. Love your work ethic mate and if you happen to find an example of my strange obsession of a 1993 Kawasaki KLX650C (electric start model) which seem to have been much more popular around your neck of the woods than they were in Australia. They were years ahead of their time and I think you would really enjoy bringing one back to life.... not that I am biased or anything! By the way, glad you finally learned to ease slightly past tdc before kicking a big bore 4-stroke single.
@varshkietukas 26 днів тому
That was a very funny video i gotta say, waiting for part 2 :D
@professorright 26 днів тому
CDI? If the CDI is bad it can come off and on. Even if it has spark a bad CDI can mess with the timing. No wonder this company went out of business. What a nightmare to work on.
@ianmangham4570 26 днів тому
Those little boxes are a pain
@MrJacksmithFTW 26 днів тому
For whom who don't know how to do it everything is a pain to do
@RimjobHimself 25 днів тому
This company is KTM today so they never went out of business.
@ianmangham4570 25 днів тому
@@RimjobHimself They make some awesome machines now ,the 125 gas gas with fuel ⛽️ injection makes 40 horses 🐎 awesome power to weight ratio.🤠💪💯
@professorright 24 дні тому
@@RimjobHimselfit’s still a piece of garbage. Who puts the battery where you can’t get it out without taking the carb out. Dumb. Technically they did go out of business as they were bought out.
@jackmundo4043 26 днів тому
Man, you earned this one. Enjoyed it. Thanks.
@davebarrowcliffe1289 26 днів тому
New air filters and starter motors are a bit expensive but seem to be easily obtainable.
@jonnyconsumer3813 18 днів тому
These were pretty awesome machines. I had an earlier FE600E that was absolute monster! There was some sort of service bulletin for the piston rings and their starters were too slow to fire the engine. There was a CBR600 starter that would swap in and worked well. The left kick was difficult with it being such a tall bike. They sound super cool and be sure you're hanging on when you sat throttle position to WFO because they'll wheelie as long as you want.
@jefftobin4034 26 днів тому
I learn something every time I watch one of your videos. Good luck finding the gremlin.
@wayne-oo 26 днів тому
Spark plugs are consumables , I don’t understand why you don’t start with a new one on every engine !!!!
@MrJacksmithFTW 26 днів тому
on the husabergs you're supposed to check the oil with engine hot. you just overfilled it bro. the oil isn't supposed to show on the window with a cold engine. another thing you should get a keihin for for it, it makes very easy to start
@anthonyblacker8471 26 днів тому
SO NICE!! When you kicked it and it went, I WISH the camera was on your face.. the look of shock must have been there, it kicked, spun up and just purred like a kitten straight to idle. What a machine!!!
@paullesarge4126 25 днів тому
Excellent video as usual. Thanks for the content.
@ClintonFrench 24 дні тому
Good video as always Joe. I think you really need the air cleaner to provide sufficient vacuum to draw the fuel up through the carburettor to get it started. Once running I am sure the air flow will draw sufficient fuel as to not run too lean. In the mean time you could try covering the carburettor opening with some foam to help create more vacuum.
@johnb4830 25 днів тому
When you try to roll-start it, have a friend pull you with another vehicle 1//2 a mile down the road, just be able to drop the tow strap quickly, with my nephews we did this a-lot, Great video, thanks
@codeman1522 25 днів тому
looks like the kick start lever returning all the way on its own is what got it going and might be a factor. might effect the auto decompression feature or timing. nice bikes them 400-500 4 strokes, i had an xr400, thumper. thanks for the content!
@bungholesrus 23 дні тому
Love your videos. I plan on doing some work on my 05 bruin 350 once i heal up from having teeth pulled. I need to replace the cv axles and oil cooler
@daveking7212 26 днів тому
when testing ohm's,dont have your fingers on the end of the probes..Your testing your body at the same tome
@tracysellman1562 26 днів тому
Yes, use alligator clamps for testing Ohms.
@Nine_883 25 днів тому
Technically true, but your ohm meter send out a voltage and that how it senses resistance. Voltage takes the path of least resistance. If he was reading his body the reading would have been a lot more resistance. Since it takes the path of least resistance he was actually reading the resistance of the stator winding.
@RimjobHimself 25 днів тому
39:50 as someone who knows a lot about this bikes. I paused now and boy im looking forward to him try to kickstart it.
@chihuahuaverde425 25 днів тому
Wow, that 400 engine looked mint!
@tonyfurneaux3399 23 дні тому
Hi, am I right, the plug tips looked different in the vid, I would always start with good new pair of plugs. Dump the old ones that come with any bike, as that could have been why the previous owner gave up...IMO, lol. Great content as usual, thanks for sharing.😁
@ceesklumper 17 годин тому
Taffmeisters in the UK specializes in Husabergs and carry tons of parts and go-even-faster parts. These are pure racing bikes.
@qacomputers3344 23 дні тому
I have a 1976 HD hardtail Chopper, did some engine work, and now it's a 1430 with NO electric start! You have to kick like a Clydesdale on that thing just because of the compression, kinda like you were kicking,,, Electric start coming very soon, that's for sure! Don't hurt yourself by kicking that beast, it's not worth a bum knee... Love your channel, keep it up!
@SirPercival1973 26 днів тому
Nice to see you working on a Swedish quality bike 😎, Percy from Sweden.
@leonardhirtle3645 25 днів тому
That must be really frustrating. Can’t wait for the next episode.
@oscarcrosstm2105 25 днів тому
Bro your channel 📈📈 this is amazing!
@MR-puffnstuff 26 днів тому
Starter one way bearing thingy is needed and missing I had same issue 2008 450 ES.
@angrysweet8932 26 днів тому
Once, in the early 2000's, I had a 350 and, once started, it was a violent monster ....!
@fan-ew4zi 21 день тому
Those bikes were an absolute weapon back in the day from early 90s very powerful and lightweight,suspension , brakes,etc..., ready to race they were smashing competition
@minibikemadman 26 днів тому
ugh these things were headaches but pretty cool...it was in the same group as the Ktm's and huskys.
@Ulster-1690 26 днів тому
Happy Days Joe Has Posted 🔥🔥🔥
@malccolliver4721 26 днів тому
Good vlog bud keep them coming 👍
@dale-qz9dg 26 днів тому
Always use a new spark plug before you tear it apart
@Stephen033 26 днів тому
That is a really cool bike. Never seen that brand before but I like it. Great work.
@jasonjavelin 26 днів тому
Not often I see a bike I’ve never even heard of before. This thing is crazy!
@skeetamacgyver1821 25 днів тому
I love your expressions of surprise and disappointment. “Haa?” and “Humf”
@petepedro350 26 днів тому
I had a 2000 501 fe. My mechanic wouldn’t touch it. Ran strong but was very finicky. And yes hard to start. Weird left side kickstarter
@darley04 25 днів тому
Welcome to the world of SEM ignitions. I can pretty much guarantee that the stator has left the chat. If you pull the stator more than likely it will be rusty and blistering. The SEM stator was the achilles heal of the Husaberg (& KTM, Husqvarna) from the mid/late 80's through to 2003. There are no new units available and the replacement stuff available from various companies are Chinese junk that will last for 1/2 an hour. You'll need to find someone that is conversant in rewinding SEM stators and you'll be good to go. FYI, that stator is shared on all Husaberg FE/FS/FX models from 1999 to 2003. From 2004 Husaberg used the Japanese Kokusan system 1989 to 1998 models used a very similar looking SEM stator but is not interchangeable
@coolnerdsclothing6377 25 днів тому
thing is a big ol money pit
@tonyaxeman4381 26 днів тому
Sounded awesome when You got to ride it . I would check out the wiring from the stater . Without a good battery and charging system it will not run or start well.
@TheStevo420 26 днів тому
Hopefully everything is in working order, I feel like if you do find the parts they will have a nice price tag 🤟🇨🇦
@axispowerdiesel 20 днів тому
Nice, I just got a sweet 2000 FE400e to go along with my 1999 FX600e, these 2nd gen engines are nightmares
@BigPoppieSeed 26 днів тому
I'm not going to lie. This video made me crack up with the left hand kick start debacle. All you were missing was the Benny Hill music. (in fast forward) and Vinny running circles around you. I hope you didn't pay to much for that contraption. "Oh yeah... my knee is really hurtin"
@Chopper650 23 дні тому
Not your problem... let's see your 100's of uploads getting bikes running again?
@chrisreussner1698 25 днів тому
Don't give up! I had a very similar KTM. Once you get your technique down it will fire right up. I recommend using your right foot to kick standing beside it. Standing on a curb to get a little height makes it WAY easier. Being able to kick straight down is the angle you want. It should have a compression release (I can see the lever at 11:48) to help you get the piston just past TDC. Finally, my bike would start when cold or when hot. However if I rode for 5 minutes and then killed it... it was a bear to start. These bikes are tricky to start but once you know what it likes you are good to go.
@za5teeshftw709 26 днів тому
the Cold revs have gotta stop let it warm up man
@AL4N. 26 днів тому
😂 your one of those guys.
@staygold902 26 днів тому
A 4 corner will happen one of these times, although this time he didn't really Rev the absolute piss out of it like usual
@dennisradle8663 26 днів тому
Rev the shit out of it. We love it
@dougiep8464 25 днів тому
You know he's doing it now as it annoys so many people, or maybe that's just what I'd do.
@randomguy1807 25 днів тому
He gets too excited and nervous because he doesn’t want it to die🤣
@adamhodson8337 25 днів тому
Having owned a couple of the older Husabergs now they are generally always a pain to start! I’ve just had the same issue with an intermittent spark on my 650 and it was the stator. We know from your testing the value on one of the tests was incorrect, so I’d definitely start there. Proper kick technique as you demonstrated is a must but I’d call Dave Clarke Racing in England for further advice. He’s probably had more Husabergs in pieces than anyone else.
@idletime 26 днів тому
G'morning Joe ☕☕ 🤠 . Wow, it's been awhile since I heard anything about Husaberg or Hodaka for that matter. I had a 0.30 over 85' Husqvarna CR 500 automatic w/ a left hand kickstart & throttle. With no compression release it was a beast 🤣🤣 .
@thatcrazyguyjay 25 днів тому
I remember I remember years ago know getting one theses but it was a 700cc I swapped it for a yz 125 and drive over 4 hours to get it I only rode it 3 or 4 times the thing was stupid fast and I’d never ridden a 700cc 2 stroke before but boy it was so much fun lol I ended up selling it in the end but awesome bikes. I can’t wait to see you sort this one out buddy awesome video as always buddy 👍👍
@CliffordDavies 19 днів тому
I had numerous Husabergs over the years but had the 1995 600 cc that was a bugger to start. tracked it down the Delortto carb and replaced with an FCR 41mm and it started on the button. To start first kick every time, start like an old British bike, three to four prime kicks with decompressor engaged, then find top dead centre then slightly past, then hard kick and it will start.
@johnhicks735 26 днів тому
Yes Joe it is 12 volt charged by the battery power source which turns on and controls the CDI box unit from the stator.
@martykath4427 25 днів тому
I've had a run on a mates FE650. What a great piece of kit for adventure riding. I've heard of these earlier ones breaking cam chain followers.
@jeredalmeida1880 26 днів тому
Even though the brand went under, Husaberg pretty much revolutionized 4Stroke technology as it was and paved the way for the modern thumpers of today. Ktm and Husky ripped so much R&D from this underdog before their early demise. The only other ones who were developing bikes like this were ATK and the Vertematti Brothers in Italy.
@dmitrijr7065 26 днів тому
Okay seriously what did they invent prior to 1995, when they were bought by KTM? This bike isn't more advanced than my 1997 LC4. Although the airbox in the frame is pretty unique
@jeredalmeida1880 26 днів тому
@@dmitrijr7065 You answered your own question. Your 97 LC4 is neck and neck with that 95 Husey. Btw Husaberg was designed by former Husky engineers who got bought out before they had to file for bankruptcy. By WHOM you might ask... At the end of the day. KTM gonna KTM.
@dmitrijr7065 26 днів тому
@@jeredalmeida1880 nope, the first Gen LC4 was launched in 1987, when husaberg wasn't even founded and you can clearly see the evolution of this bike from 1988 to 2006, but the overall design wasn't changed much. Later under KTM Husaberg had some really interesting design ideas but in the 90ies? Can't see much
@jeredalmeida1880 26 днів тому
@@dmitrijr7065 Well you wrote 1997.
@jeredalmeida1880 26 днів тому
@@dmitrijr7065 Ya wrote 1997. I'd never heard of a 97 LC4 until today. That threw me off
@Edward-turtle 22 дні тому
its nice that it has cup holders on the side bits.
@ZmZ100 25 днів тому
never ever heard of this brand , this is a sick bike that exhaust is crazy
@chuckclark9464 26 днів тому
You ever notice everybody’s telling you that they always run one way or another somebody’s told you it ran through somebody else or whatever lol when you were using the electric start, it did spark a little bit. I did see it.
@Skidderoperator 26 днів тому
Stator or wire problem?
@mriippa 13 днів тому
i dream of owning a dirtbike, and you have one for every day of the week. lucky you.
@luuk-out-below9804 26 днів тому
To the squat rack Joe, no more skipping leg day when you got one of these!!!
@user-fi3fx5my2s 26 днів тому
Clean magneto, should sharpen spark up.
@st7650 18 днів тому
Now I know why the company went out of business what type of engineers would design something that you can’t replace the battery without pulling the engine. Just saying they apparently didn’t build the bike to be worked on. Love the channel thanks for the post
@Max1290. 24 дні тому
Didnt even know these existed in the US. They're quite popular where i live🇩🇪 Unfortunately the company went out of business in 2014😢
@ZenWithKen 25 днів тому
Have you ever come across a brand by the name of Hodaka? I had one back in the late 70's. Thanks for sharing!
@user-np5rd6dg3o 26 днів тому
My grandson traded a ttr250 for a husaberg fe450 2004 that had a gear box issue which we repaired. It started with the electric start first touch of the button. He now rides it regularly it is a great bike, he now has picked up an fe501 1999 and we plan to have it running soon.
@garageassembled4701 25 днів тому
Try pulling the stator and cleaning the contact area’s. I pulled mine and wiped it and it help tremendously in starting.
@johnhicks735 26 днів тому
I've got A suggestion to on that issue. It is to check over all of the plug-in connectors and wires. where they click into those plastic connector plug-in block fittings. To each other separately as one wiring harness design set-up. And another thing I'd check that woodruff key it could be chipped.,or Bent.,or worn down from over the years of use to. And one more time Joe yes you can check CDI boxes by using The same multimeter.,or flukemeter that you checked the stator with it's kinda the same process. only your checking it in either ohms.,or continuity mode usually it's on continuity mode though.
@ktmeric66 24 дні тому
I'm not sure about the inconsistent spark, but there is a routine to starting them. I think you kick them through until just past TDC, then give a good kick. Also turn the idle screw up a little. I'll ask a friend who owned a Husaberg shop to watch the video
@dmitrijr7065 26 днів тому
Not familiar with this bike, but i know KTMs from the 90ies used a SEM Ignition system, which was really hard to start (hence "Kick ten Minutes") and broke easily. Your spark on/off problem in combination with the inconsitent electric resistance measurement are pointing into the direction of the stator
Comedy Club
Переглядів 4,2 млн
Champions of the Future Academy Program
Переглядів 2,7 тис.
I Finished A Video Game
Переглядів 5 млн
2vintage
Переглядів 741 тис.
Pole Barn Garage
Переглядів 13 тис.
2vintage
Переглядів 316 тис.